Peugeot Partner reliability

Affected vehicles may have incorrect or missing information on the tyre pressure label.

Fix: Replace the tyre pressure label.

Recalled models: PARTNER · 1,461 vehicles

Vehicles may be affected by premature wearing of the camshaft drive chain leading to abnormal noise or to a breakage of the chain in the worst case.

Fix: Update the software to improve oil pressure and reduce wear. Check the engine noise and replace the chain if required. If no problem found change the oil to one with higher viscosity and special anti-wear additives.

Recalled models: PARTNER · 26,138 vehicles

Affected vehicles may face an error in the Battery Monitoring Unit software.

Fix: Update the Battery Monitoring Unit software.

Recalled models: PARTNER · 393 vehicles

Affected vehicles may face an error in the Battery Monitoring Unit software.

Fix: Change the ATB.

Recalled models: PARTNER · 8 vehicles

On affected vehicles the AC compressor stator wiring could develop a fault leading to current loss inside the AC compressor that could result in a vehicle powertrain shutdown when driving.�

Fix: Reprogram the Powertrain Diagnosis ECU with updated software.

Recalled models: PARTNER · 29,537 vehicles

There is an error in the software calibration of the traction battery control unit which could result in a loss of propulsion when driving.

Fix: Update the software of the traction battery control unit.

Recalled models: PARTNER ELECTRIC · 1,610 vehicles

On the affected vehicles the operation of the brake vacuum pump may be affected by material detaching from the timing belt caused by the ageing of the engine oil.

Fix: To rectify this issue a software update will be downloaded which will improve the vacuum diagnosis (in order to warn earlier about the risk of loss or reduction of braking assistance). The timing belt will be checked and if needed replaced with other components of the braking assistance system and the vacuum pump.

Recalled models: PARTNER V3 · 952 vehicles

On the affected vehicles the operation of the brake vacuum pump may be affected by material detaching from the timing belt caused by the ageing of the engine oil.

Fix: To rectify this issue a software update will be downloaded which will improve the vacuum diagnosis (in order to warn earlier about the risk of loss or reduction of braking assistance).

Recalled models: PARTNER V3 · 25,148 vehicles

The possibility that the lower metal engine protection guard could trap material between it and the underside of the engine exhaust system

Fix: : Replace the metal under engine protection guard with a different design to prevent the collection of material.

Recalled models: PARTNER · 1,727 vehicles

The brake vacuum pump may be affected by material detaching from the timing belt.

Fix: Update detection software inspect and if necessary replace vacuum pump and timing belt.

Recalled models: PARTNER V3 · 22,580 vehicles

The inner tie rods connecting the steering rack to the track rod end are not correct to specification

Fix: Replace the steering rack inner tie rods (on both sides)

Recalled models: PARTNER · 51 vehicles

The urea injector may temporarily block

Fix: Update the engine management software.

Recalled models: PARTNER · 11 vehicles

Steering columns were produced not according to specification.

Fix: Replacement of the steering column.

Recalled models: PARTNER · 62 vehicles

The passenger outer seat belts may not be correct to specification

Fix: Replace the front outer passenger seat belt.

Recalled models: PARTNER · 12,007 vehicles

On the affected vehicles an internal component within the airbag triggering ECU may have been damaged which could lead to non deployment. There are no early warning signs or symptoms for the customer to indicate if the ECU is incorrect.

Fix: The manufacturer has no simple method to check the internal component. Therefore all ECU's in affected vehicles to be changed as a precaution.

Recalled models: PARTNER · 124 vehicles

An engine component may not be to specification which could result in loss of engine performance. This may lead to the engine stalling and potentially causing an engine failure. In very unlikely circumstances the vehicle speed may increase without warning but will stop on its own after a few seconds.

Fix: On affected vehicles carry out a functional diagnostic check of the engine. If necessary replace the engine.

Recalled models: PARTNER TEPEE (89) · 416 vehicles

A component in the gearbox actuator may not be to the correct specification which may affect gear selection.

Fix: On affected vehicles replace the gearbox actuator

Recalled models: PARTNER III · 13 vehicles

The bonnet may not close correctly over time because a possible non-conformity with the fixing of the bonnet catch. The driver may notice in certain cases difficulty in opening or closing the bonnet easily or vibrations or slight movement of the bonnet when driving. The risk is incorrect closing of the bonnet which could lead without any warning to unwanted opening when driving.

Fix: Recall the the vehicles that are likely to be affected and check the front bumper support. Where necessary the front bumper support will be replaced.

Recalled models: PARTNER · 220 vehicles

On affected vehicles the driver's air bag inflation device may not conform to specification. As a result may not deploy correctly during an impact.

Fix: Replace the driver's air bag module on affected vehicles

Recalled models: PARTNER · 797 vehicles

It has been established that the high pressure fuel rail pipes on the engine have not been torqued to the correct specification. This can result in poor sealing of the rail which can cause as fuel leak onto the engine. If the vaporised fuel comes into contact with a hot engine component there can be a risk of an engine bay fire.

Fix: Recall all the affected vehicles and retorque the high pressure fuel rail pipes.

Recalled models: PARTNER III · 148 vehicles

The fixing bolts of the front LH and RH seat belt return rail may loosen and in cases of extreme force break.

Fix: The bolts on the left and right- hand sides will be replaced.

Recalled models: PARTNER · 56 vehicles

The roof panel rear flap hinge may have a defect which will eventually allow the roof panel to detach.

Fix: Recall the vehicles that are likely to be affected to either reinforce the retention of the hinges or changing the roof panel rear flap.

Recalled models: PARTNER · 9 vehicles

The passenger airbag wiring harness connector may not be to specification which can cause the illumination of the warning light on the dash or if involved in a impact the incorrect deployment of the airbag.

Fix: Recall all affected vehicles and replace the passenger airbag wiring harness.

Recalled models: PARTNER · 138 vehicles

It has been identified that the possibility exists that the mounting ball on both tailgate support struts may rotate when the tailgate is opened or closed. Should one of the support struts dislocate the tailgate may not remain in the open position.

Fix: Recalled vehicles will have the mounting ball joints on the tailgate support struts replaced.

Recalled models: PARTNER · 17 vehicles

The heat shield protecting the spare wheel and carrier may detach because of the vibrations it is subjected to.

Fix: Recall the vehicles that are likely to be affected to modify the heat shield or where necessary replace the spare wheel carrier which incorporates the heat shield.

Recalled models: PARTNER · 2,040 vehicles

The left hand rear seat may not be fully secure because the right hand seat fixing may have been welded incorrectly. If the weld is incorrect the seat may detach during an accident.

Fix: Recall the vehicles that are likely to be affected to check and where necessary repair the seat fixing.

Recalled models: PARTNER · 1 vehicles

It has been identified that the main engine fuse box is not to the correct specification. This can result in operating faults or the failure of certain equipment.

Fix: Recalled vehicles will have the subject fuse box replaced.

Recalled models: PARTNER · 7,360 vehicles

In countries where salt is used extensively on the roads the paint sub layer on certain springs produced over a specific manufacturing period shows very little resistance to corrosion. This can in exceptional circumstances cause a front suspension spring to break with the attendant risk that the spring could contact the tyre.

Fix: To prevent an occurrence of this type likely to be affected vehicles will be recalled at which time a suspension cup will be fitted on each front side of the vehicle to prevent a failed spring from making contact with the tyre.

Recalled models: PARTNER · 32,396 vehicles

The airbag Electronic Control Unit (ECU) is incorrect to specification this reduces the number of impact configurations taken into consideration when activating the airbags. So an airbag may not deploy in as many advantageous situations.

Fix: Recall the vehicles that are likely to be affected and replace the airbag ECU.

Recalled models: PARTNER · 5,912 vehicles

Internal tyre tread may have been damaged during fitting which could lead to a loss of pressure.

Fix: Recall affected vehicles and replace all five tyres.

Recalled models: PARTNER · 2 vehicles

There is a possibility that the front stub axle on one or both sides of the vehicle may have been incorrectly machined. This could result in excessive wear the lower ball joint becoming displaced and the collapse of the suspension.

Fix: Recall affected vehicles and check and if necessary replace both front stub axles.

Recalled models: PARTNER · 4,630 vehicles

There is a possibility that the brake servo valve may not function correctly resulting in loss of servo assistance to the braking system.

Fix: Recall affected vehicles for the inspection and possible replacement of the brake servo valve.

Recalled models: PARTNER · 18,405 vehicles

The main underbonnet harness may become damaged through chafing on the scuttle panel. This could result in stalling and loss of electrical functions.

Fix: Affected vehicles are being recalled for the fitment of a protective sleeve to the main wiring harness to prevent chaffing.

Recalled models: PARTNER · 1,411 vehicles